无损检测 磁粉检测用材料
Non-destructive testing - Materials for magnetic particle testing
1 范围
1 Scope
本标准规定了磁粉检测用材料(或检测介质，包括磁悬液、干磁粉、载液、反差增强剂)的分类、技术要求和检验方法等。
This standard specifies the classification, technical requirements and inspection methods of materials (or testing medium, including magnetic ink, dry magnetic powders, carrier fluid and contrast aid paints) for magnetic particle testing.
本标准适用于检测介质的型式检验和批量检验。
This standard is applicable to type inspection and batch inspection of testing medium.
本标准也可作为用户订货的验收依据。
It may also be used as the basis for acceptance of user orders.
2 规范性引用文件
2 Normative references
下列文件中的条款通过本标准的引用而成为本标准的条款。凡是注日期的引用文件，其随后所有的修改单(不包括勘误的内容)或修订版均不适用于本标准，然而，鼓励根据本标准达成协议的各方研究是否可使用这些文件的最新版本。凡是不注日期的引用文件，其最新版本适用于本标准。
The following normative documents contain provisions which, through reference in this text, constitute provisions of this standard. For dated references, subsequent amendments (excluding corrections), or revisions, of any of these publications do not apply to this standard. However parties to agreements based on this standard are encouraged to investigate the possibility of applying the most recent editions of the normative documents indicated below. For undated references, the latest edition applies.
GB/T 265 石油产品运动粘度测定法和动力粘度计算法
Petroleum products - Determination of kinematic viscosity and calculation of dynamic viscosity
GB/T 699 优质碳素结构钢
Quality carbon structure steels
GB/T 2007.7 散装矿产品取样、制样通则 粒度测定方法 手工筛分法(GB/T 2007.7—1987，neq ISO 2591：1982)
General rules for the sampling and sample preparation of minerals in bulk - The method for determination of size by manual sieving (GB/T 2007.7-1987, neq ISO 2591:1982)
GB/T 5097 无损检测 渗透检测和磁粉检测 观察条件(GB/T 5097—2005，ISO 3059：2001，IDT)
Non-destructive testing - Penetrant testing and magnetic particle testing - Viewing conditions (GB/T 5097-2005, ISO 3059: 2001, IDT)
GB/T 6368 表面活性剂 水溶液pH值的测定 电位法(GB/T 6368—1993，eqv ISO 4316：1977)
Surface active agents - Determination of pH of aqueous solution - Potentiometric method (GB/T 6368-1993, eqv ISO 4316:1977)
GB/T 8034 焦化苯类产品铜片腐蚀的测定方法(GB/T 8034—1987，eqv ISO 2160：1972)
Benzol products of coal carbonization - Corrosiveness to copper - Copper strip test (GB/T 8034-1987, eqv ISO 2160:1972)
GB/T 12604.5 无损检测术语 磁粉检测
Non-destructive testing - Terminology - Terms used in magnetic particle testing
GB/T 15822(所有部分)
GB/T 15822 (All parts) 无损检测 磁粉检测(GB/T 15822.1〜3—2005，ISO 9934-1：2001，ISO 9934-2〜3：2002，IDT)
Non-destructive testing - Magnetic particle testing (GB/T 15822.1~3-2005, ISO 9934-1:2001, ISO 9934-2~3:2002, IDT)
JB/T 7523-2004 无损检测 渗透检测用材料
Non-destructive testing - Materials for penetrant testing
3 术语和定义
3 Terms and definitions
GB/T 12604.5中确立的术语和定义适用于本标准。
For the purpose of this standard, the terms and definitions established in GB/T 12604.5 apply.
4 安全预防
4 Safety precautions
磁粉检测用材料及其检验用的化学制品，可能是有害的、易燃的和(或)易挥发的，因此宜遵守各项规定的预防措施。应遵守国家和地方颁布的所有关于安全卫生、环保要求的法规。
Materials for magnetic particle testing and chemicals for inspection may be harmful, flammable and/or volatile, so the precautions should be followed. All national and local laws and regulations on safety, sanitation and environmental protection shall be observed.
